Nissan Xterra

Defect: NISSAN HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2010 FRONTIER, PATHFINDER, AND XTERRA VEHICLES MANUFACTURED FROM FEBRUARY 22, 2010 TO MARCH 13, 2010. ON SOME OF THE POTENTIALLY AFFECTED VEHICLES, THE FASTENERS SECURING THE PASSENGER FRONT AIR BAG MODULE, AND ALSO THE FASTENERS SECURING THE STEERING SHAFT POSITIONING BRACKET MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION.

Risc: IN THE EVENT OF A CRASH, THE PASSENGER FRONT AIR BAG DEPLOYMENT TRAJECTORY MIGHT BE AFFECTED. THE FASTENERS COULD POSSIBLY COME OUT OF THE STEERING COLUMN POSITIONING BRACKET INCREASING THE RISK OF A CRASH.

Remediul producătorului: DEALERS WILL INSPECT THE STEERING COLUMN AND THE PASSENGER FRONT AIR BAG FASTENERS AND ANY MISSING FASTENERS WILL BE REPLACED AND ALL LOOSE FASTENERS WILL BE RETIGHTENED TO THE PROPER TORQUE SPECIFICATIONS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 19, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Defect: ON CERTAIN SPORT UTILITY VEHICLES, THE ANTILOCK BRAKE SYSTEM/VEHICLE DYNAMIC CONTROL (ABS/VDC) ACTUATOR IS DESIGNED WITH ONE BALL IN THE VALVE SECTION. SOME ABS/VDC ACTUATORS WERE MANUFACTURED WITH MORE THAN ONE BALL IN THE VALVE.

Risc: IN ABS/VDC ACTUATORS WITH MORE THAN ONE BALL, IT IS POSSIBLE THAT FLUID FLOW COULD BE BLOCKED AND CAUSE A REDUCTION IN BRAKE FORCE IN ONE OR BOTH FRONT WHEELS OR AFFECT OPERATION OF THE ABS AND/OR VDC. THIS COULD RESULT IN A REDUCTION IN BRAKE EFFECTIVENESS WITHOUT WARNING INCREASING THE RISK OF A CRASH.

Remediul producătorului: DEALERS WILL REPLACE THE ABS/VDC ACTUATOR WITH A NEW ONE. THE RECALL BEGAN ON DECEMBER 31, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Defect: NISSAN IS RECALLING 5,523 MY 2008 TITAN, FRONTIER AND XTERRA VEHICLES FOR FAILING TO COMPLY TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES.' THE TIRE PLACARD LISTS AN INCORRECT VEHICLE CAPACITY WEIGHT.

Risc: THIS STANDARD SPECIFIES REQUIREMENTS FOR TIRE SELECTION TO PREVENT OVERLOADING.

Remediul producătorului: NISSAN WILL MAIL A CORRECT TIRE PLACARD AND INSTALLATION INSTRUCTIONS TO OWNERS OF THE AFFECTED VEHICLES. THE RECALL BEGAN ON FEBRUARY 25, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Defect: CERTAIN CONTINENTAL AUTOMOTIVE ABS AND ESC CONTROL MODULES SOLD FOR INSTALLATION ON THE VEHICLES LISTED ABOVE. SOME OF THE HYDRAULIC VALVES IN THE ESC MODULE WERE BUILT WITH EXTRA CHECK BALLS.

Risc: THE EXTRA CHECK BALLS CAN RESTRICT THE FLOW OF BRAKE FLUID THROUGH THE VALVE AND CAUSE REDUCTION OF BRAKE FORCE.

Remediul producătorului: EACH VEHICLE MANUFACTURER WILL FILE A DEFECT REPORT AND REMEDY PLAN FOR THEIR VEHICLES WHICH INCLUDED THESE MODULES AS ORIGINAL EQUIPMENT. VEHICLES WILL BE REPAIRED AT NO COST TO THE OWNER. OWNERS CAN CONTACT EITHER THEIR VEHICLE MANUFACTURER OR CONTINENTAL AUTOMOTIVE AT 248-393-5300 FOR FURTHER INFORMATION.

Defect: ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A NISSAN ACCESSORY TOW HITCH, INADEQUATE QUALITY OF SOME WELDED JOINTS IN THE HITCH ASSEMBLY MAY RESULT IN SEPARATION OF THE HITCH FROM THE VEHICLE WHEN BEING USED TO TOW.

Risc: THIS COULD RESULT IN THE TRAILER SEPARATING FROM THE VEHICLE AND CAUSE A CRASH WITHOUT WARNING.

Remediul producătorului: DEALERS WILL REPLACE THE TOW HITCHES. ON OCTOBER 17, 2005, OWNERS WERE SENT AN INTERIM LETTER ADVISING THEM NOT TO USE THE TOW HITCH UNTIL IT CAN BE REPAIRED. ANOTHER LETTER WAS SENT OUT ON NOVEMBER 21, 2005, NOTIFYING THEM TO BRING THEIR VEHICLES IN FOR REPAIR. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Defect: ON CERTAIN SPORT UTILITY VEHICLES, THE ACCESSORY TOW HITCH ATTACHMENT BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.

Risc: THIS COULD CAUSE THE TOW HITCH TO LOOSEN OR SEPARATE FROM THE VEHICLE WHICH COULD RESULT IN A CRASH WITHOUT WARNING.

Remediul producătorului: DEALERS WILL TIGHTEN THE TOW HITCH. THE RECALL BEGAN ON JANUARY 3, 2005. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.

Defect: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH A SUPERCHARGER, UNDER CERTAIN CONDITIONS, SUCH AS FULL THROTTLE IN LOW GEAR WHEN THE ENGINE IS NOT FULLY WARMED UP AND AT COLD AMBIENT TEMPERATURE, THE AMOUNT OF INTAKE AIR FLOW THROUGH THE AIR FLOW METER MAY EXCEED THE MAXIMUM PRESET DIAGNOSIS LIMIT VALUE.

Risc: THIS WILL CAUSE THE ENGINE CONTROL SYSTEM TO GO INTO THE FAILSAFE MODE. UNDER THIS CONDITION, THE MALFUNCTION INDICATOR LAMP WILL ILLUMINATE AND ENGINE SPEED WILL NOT EXCEED 2400 RPM REGARDLESS OF THE THROTTLE POSITION, INCREASING THE RISK OF A CRASH.

Remediul producătorului: DEALERS WILL REPROGRAM THE ELECTRONIC CONTROL MODULE. OWNER NOTIFICATION BEGAN JANUARY 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Defect: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.

Risc: THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.

Remediul producătorului: DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Defect: 2000 NISSAN XTERRA VEHICLES MANUFACTURED BETWEEN OCTOBER 15, 1999, AND FEBRUARY 29, 2000. THE ALLOY WHEELS USED ON THESE VEHICLES MAY NOT HAVE BEEN PROPERLY MANUFACTURED AND COULD DEVELOP CRACKS IN THE WHEEL SPOKES.

Risc: IF A SUFFICIENT NUMBER OF SPOKE CRACKS DEVELOP, THE WHEEL COULD FAIL AND SEPARATE FROM THE MOUNTING HUB, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.

Remediul producătorului: NISSAN WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FOUR ALLOY WHEELS WITH XTERRA SE MODEL BRIGHT ALLOY WHEELS FREE OF CHARGE. THE SPARE TIRE STEEL WHEEL IS NOT AFFECTED. OWNER NOTIFICATION BEGAN ON SEPTEMBER 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. INFORMATION CAN ALSO BE OBTAINED THROUGH NISSAN'S WEB SITE AT WWW.NISSANUSA.COM.