Ford Thunderbird

Defect: ON CERTAIN PASSENGER VEHICLES, THE DRIVER'S SIDE SEAT BELT CONTACTED THE SEAT RECLINER DURING A 35 MPH NCAP FULL-FRONTAL BARRIER IMPACT TEST.

Risc: THE EDGE OF THE RECLINER MECHANISM CAUSED A PARTIAL CUT IN THE LAP PORTION OF THE WEBBING. IF THE WEBBING IS CUT, IT INCREASES THE RISK OF INJURY IN A CRASH.

Remediul producătorului: DEALERS WILL INSTALL AN INSERT BEHIND THE DRIVER SIDE SEAT LOWER TRIM PANEL. OWNER NOTIFICATION BEGAN JUNE 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.

Risc: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.

Remediul producătorului: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.

Defect: THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.

Risc: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.

Remediul producătorului: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.

Defect: BATTERY TO STARTER CABLES ARE LONGER THAN SPECIFIED; EXCESSIVE CABLE LENGTH COULD CONTACT ENGINE DAMPER PULLEY.

Risc: CABLE PROTECTIVE COVERING AND INSULATION COULD WEAR THROUGH AND CAUSE A DIRECT SHORT TO GROUND, RESULTING IN OVERHEATING OF THE CABLE INSULATION AND POSSIBLY A UNDERHOOD FIRE.

Remediul producătorului: REPLACE BATTERY TO STARTER CABLE WITH CORRECT LENGTH CABLE.

Defect: IMPROPERLY HEAT TREATED REAR SUSPENSION KNUCKLES COULD EXPERIENCE HIGH MILEAGE FATIGUE CRACKS AND EVENTUAL FRACTURE.

Risc: THIS COULD RESULT IN REAR SUSPENSION FAILURE AT THEAFFECTED WHEEL WITH AN ADVERSE AFFECT ON CONTROL OF THE CAR, WHICH COULDCAUSE AN ACCIDENT.

Remediul producătorului: REPLACE KNUCKLES THAT HAVE THE AFFECTED LOT CODES.

Defect: A DESIGN CHANGE TO FACILITATE CHANGEOVER IN REAR AXLE SHAFT FLANGES INADVERTENTLY PRODUCED THE POSSIBILITY FOR INTERFERENCE BETWEEN THE FLANGE AND DISC BRAKE ROTOR.

Risc: THE INTERFERENCE COULD PREVENT PROPER SEATING OF THEROTOR. ALSO AN IMPROPERLY SEATED ROTOR COULD IN TIME RESULT IN A REDUCTION INTHE CLAMPING FORCES OF THE WHEEL STUDS, POSSIBLY LEADING TO FRACTURED STUDSAND REAR WHEEL SEPARATION.

Remediul producătorului: INSPECTION OF VEHICLES AND WHERE NECESSARY REPLACE REAR AXLE SHAFTS AND REAR BRAKE ROTORS.

Defect: FUEL LEAKS COULD DEVELOP IN EITHER OF TWO CONNECTIONS IN A FUEL SUPPLY LINE. ONE CONNECTION UNDER THE VEHICLE MAY HAVE BEEN DAMAGED OR IMPROPERLY INSTALLED. THE OTHER SUSPECT PART IS IN THE ENGINE COMPARTMENT AND CONTAINS A PRESSURE RELIEF VALVE.

Remediul producătorului: THE DEALER WILL INSTALL A REVISED DESIGN FUEL LINE VALVE ASSEMBLY WITH NEW HOSE CLAMPS AND REPLACE THE FUEL SUPPLY HOSE CLAMP, IF IT IS DAMAGED OR INCORRECT. NOTIFICATION WAS MADE TO DEALERS PRIOR TO ANY RECORDED VEHICLE SALES, AND VEHICLES SHOULD HAVE BEEN CORRECTED BEFORE FINAL DELIVERY.

Defect: THE PARKING GEAR MAY NOT ENGAGE, EVEN THOUGH THE GEAR SHIFT LEVER IS PLACED IN THE "PARK" POSITION. THIS OCCURS IF THE LINKAGE INSIDE THE TRANSMISSION THAT ACTUATES THE PARK GEAR WAS IMPROPERLY MANUFACTURED. A PIN THAT RETAINS COMPONENTS ON A LINKAGE (ACTUATING) ROD COULD BREAK AND THE LINKAGE MAY NOT ENGAGE THE PARKING GEAR.

Remediul producătorului: DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE PARKING PAWL ACTUATING ROD ASSEMBLY.

Defect: THE INVOLVED VEHICLES WERE FITTED WITH TILT STEERING COLUMNS CONTAINING TRANSMISSION CONTROL INSERTS INTENDED FOR TRUCKS RATHER THAN PASSENGER VEHICLES. THIS MAY CAUSE THE TRANSMISSION SELECTOR POINTER TO BE MISALIGNED AND THE POSSIBILITY OF STARTING THE ENGINE WHEN THE SELECTOR IS BETWEEN THE NEUTRAL (N) AND DRIVE (D) DETENTS AND THE TRANSMISSION IS IN DRIVE.

Remediul producătorului: DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE TRANSMISSION SHIFT CONTROL INSERT, WITHOUT CHARGE TO OWNER.

Defect: THE INVOLVED VEHICLES MAY HAVE BEEN EQUIPPED WITH CAST ALUMINUM WHEELS WITH INADEQUATE LUG NUT COUNTERBORE DEPTHS. THIS CONDITION MAY NOT PROVIDE SUFFICIENT LUG NUT THREAD ENGAGEMENT. THE LUG NUTS MAY LOOSEN AND FALL OFF, ALLOWING THE WHEEL TO SEPARATE FROM THE VEHICLE.

Remediul producătorului: DEALER WILL INSPECT AND, IF NEESSARY, WILL REPLACE THE WHEELS WITHOUT CHARGE TO OWNER.