Volkswagen Rabbit

Difetto: THE THROTTLE SHAFT OF THE CARBURETOR MAY CRACK AND EVENTUALLY BREAK AT THE THREADED HOLE FOR THE THROTTLE PLATE CONNECTION DUE TO EXCESSIVE VIBRATION OF THE THROTTLE SHAFT. CONSEQUENCE OF DEFECT: IF THE THROTTLE SHAFT BREAKS, THE THROTTLE WOULD NOT RETURN TO ITS IDLE POSITION. THIS COULD RESULT IN LOSS OF CONTROL AND AN ACCIDENT.

Rimedio del costruttore: INSTALL A REINFORCEMENT PLATE IF THERE IS NO CRACK IN THE THROTTLE SHAFT. INSTALL A NEW CARBURETOR WITH REINFORCED THROTTLE SHAFT IF A HAIRLINE CRACK HAS DEVELOPED IN THE SHAFT.

Difetto: ON SOME VEHICLES, THE PRESSURE COULD INCREASE INSIDE THE FUEL TANK FROM HIGH SURROUNDING TEMPERATURES WHEN THE FUEL TANK IS MORE THAN HALF FULL.

Rimedio del costruttore: DEALER WILL INSTALL A RESTRICTOR VALVE INTO THE FUEL FILLER PIPE, WITHOUT CHARGE TO OWNER.

Difetto: BRAKE LINES INSTALLED UNDERNEATH THE CARPETING IN THE PASSENGER COMPARTMENT MAY RUST DUE TO THE ENTRY OF WATER AND ROAD SALT. IF RUSTING REMAINS UNCHECKED, IT PRODUCES LEAKS IN THE LINES AND BRAKE FLUID MAY BE LOST.

Rimedio del costruttore: THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE INTERIOR BRAKE LINES AT NO COST TO OWNER. OWNERS ARE ALSO ADVISED THAT ALL BRAKE LINES SHOULD BE INSPECTED AT TWO-YEAR INTERVALS.

Difetto: THE FUEL PUMP MAY STOP FUNCTIONING WITHOUT WARNING. THIS CAN OCCUR BECAUSE AN ELECTRICAL CONNECTOR IN THE FUSE PANEL MAY OVERHEAT AND INTERRUPT THE ELECTRICAL CIRCUIT.

Rimedio del costruttore: DEALER WILL INSPECT THE FUSE BOX AND ITS CONNECTORS FOR CORROSION, AND CORRECT WHERE NECESSARY. A BYPASS ADAPTER TO THE FUEL PUMP ELECTRICAL CIRCUIT WILL BE INSTALLED.

Difetto: CORROSIVE DAMAGE AND INCREASED ELECTRICAL RESISTANCE MAY CAUSE THE FUEL PUMP RELAY TO STOP FUNCTIONING. THE FUEL PUMP RELAY IS ONE OF SEVERAL RELAYS ON A RELAY BOARD LOCATED NEAR THE FIREWALL. CORROSION CAUSED BY RAIN ENTERING AN IMPROPERLY SEALED ANTENNA HOLE HAS BEEN THE SUBJECT OF PREVIOUS CAMPAIGNS, BUT ADDITIONAL MEASURES ARE REQUIRED TO ENSURE THAT THE PROBLEM IS CORRECTED.

Rimedio del costruttore: VEHICLES WILL BE INSPECTED TO DETERMINE WHETHER THE MODIFICATION HAS BEEN PERFORMED. IF NOT, A BYPASS WILL BE INSTALLED TO LOCATE THE FUEL PUMP RELAY AWAY FROM THE RELAY BOARD. ANY CORRODED RELAY BOARDS OR CONNECTORS WILL ALSO BE REPLACED.

Difetto: ON SOME VEHICLES, THE FENDER OPENING THROUGH WHICH THE ANTENNA CABLE IS ROUTED MAY NOT BE PROPERLY SEALED. AS A RESULT, SPLASHED WATER FROM THE TIRES COULD ENTER PASSENGER COMPARTMENT THROUGH THE OPENING, ENTER THE FUSE RELAY BOARD AND CAUSE CORROSION OF THE TERMINALS. ALSO, BECAUSE WATER IS A GOOD CONDUCTOR OF ELECTRICITY, THE STARTER CAN BE ACTIVATED ACCIDENTALLY; THE HIGH FLOW OF ELECTRICITY MAY EXHAUST THE BATTERY WITHIN A SHORT PERIOD OF TIME. THUS RESTARTING THE ENGINE WOULD BECOME IMPOSSIBLE AND PARKING LIGHTS AND EMERGENCY FLASHERS WOULD BECOME INOPERATIVE.

Rimedio del costruttore: DEALER WILL INSPECT AND, IF NECESSARY, SEAL THE RADIO ANTENNA HOLES AND REPLACE CORRODED COMPONENTS WITHOUT CHARGE TO OWNER..

Difetto: DUE TO AN IMPROPERLY SEALED ANTENNA MOUNTING HOLE, WATER COULD SEAP INTO THE FUSE RELAY BOARD. THE WATER ENTERING THE FUSE RELAY BOARD ACTS AS A CONDUCTOR OF CURRENT, THEREBY CHARGING THE STARTER.

Rimedio del costruttore: THE DEALER WILL SEAL ALL RADIO ANTENNA CABLE HOLES. IN ADDITION, ELECTRICAL PARTS OF THE RELAY/FUSE BOARD WILL BE CHECKED AND REPLACED IN THE CASE OF CORROSION.

Difetto: THE REAR AXLE BRAKE CABLE BRACKET IS ATTACHED TO THE OUTSIDE OF A FLANGE BOLT OF THE REAR AXLE. THIS BRACKET WAS NOT CORRECTLY INSTALLED DURING ASSEMBLY.

Rimedio del costruttore: THE DEALER WILL RELOCATE THE BRACKET AND INSTALL A NEW FLANGE, IF NECESSARY, WITHOUT CHARGE.

Difetto: ON THE INVOLVED VEHICLES, THE TWO RUBBER ELBOWS, LOCATED AT EACH END OF THE PLASTIC PIPE LEADING FROM THE THROTTLE VALVE BODY HOUSING TO THE BRAKE BOOSTER VACUUM PUMP, MAY BE DAMAGED AS A RESULT OF IMPROPER CLAMP INSTALLATION.

Rimedio del costruttore: THE DEALER WILL REPLACE THE RUBBER ELBOW CONNECTIONS AND INSTALL NEW TYPE CLAMPS, WITHOUT CHARGE TO OWNER.

Difetto: THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC BRAKE SYSTEMS". THE INVOLVED VEHICLES WERE INADVERTENTLY EQUIPPED WITH A BRAKE FLUID CONTAINER CAP ON WHICH THE WARNING TEXT WAS PRINTED IN GERMAN.

Rimedio del costruttore: THE DEALER WILL INSTALL A SUPPLEMENT LABEL, PRINTED IN ENGLISH, ON THE BRAKE FLUID CONTAINER, DISPLAYING THE REQUIRED STATEMENT, FREE OF CHARGE.

Difetto: ON THE INVOLVED VEHICLES, THE VACUUM LINE CONNECTING THE CARBURETOR AND THE THERMO VALVE MAY HAVE BEEN IMPROPERLY INSTALLED. THIS CONDITION MAY PREVENT THE THROTTLE LINKAGE PLATE FROM RETURNING TO ITS IDLE POSITION.

Rimedio del costruttore: THE DEALER WILL REPLACE THE VACUUM HOSE WITH A LONGER VERSION HOSE, REROUTING AND SECURING IT, WITHOUT CHARGE TO OWNER.