Ford F Series

Difetto: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. THE FRONT END ACCESSORY DRIVE (FEAD) SERPENTINE DRIVE BELT CAN DETACH FROM THE ENGINE PULLEYS DURING CERTAIN ENGINE OPERATIONS. THE DIESEL ENGINE CAN CAUSE THE BELTS TO STRETCH IN EXCESS OF THE TENSIONER CAPACITY AND THE BELT DETACHES FROM THE PULLEYS.

Rischio: BELT FAILURES CAN RESULT IN THE LOSS OF POWER STEERING ASSIST AND THE LOSS OF BRAKE ASSIST ONCE THE VACUUM RESERVOIR IS DEPLETED. ALSO FEAD BELT FAILURE POSES A RISK OF ENGINE COMPARTMENT FIRE IN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS IF IT RESULTS IN THE TRANSMISSION OIL COOLER HOSE RUPTURE.

Rimedio del costruttore: DEALERS WILL INSTALL A NEW TENSIONER, DRIVE BELT, BELT GUIDE AND AN IMPROVED IDLER PULLEY.

Difetto: INCORRECT SIZE MASTER CYLINDER INSTALLED WILL PROVIDE LESS LINE PRESSURE TO WHEEL CYLINDERS FOR A GIVEN PEDAL PRESSURE.

Rischio: THIS COULD RESULT IN INCREASED STOPPING DISTANCES ORINCREASED PEDAL PRESSURE REQUIRED FOR A GIVEN STOPPING DISTANCE, WHICH COULDCAUSE AN ACCIDENT.

Rimedio del costruttore: INSTALL THE CORRECT 1.75 INCH MASTER CYLINDER.

Difetto: INTERCONNECTION OF RETURN LINE PLUMBING FROM HYDROBOOST STEERING GEAR MAY CAUSE LIGHT APPLICATION OF HYDROBOOST UNIT WITHOUT APPLYING BRAKE PEDAL.

Rischio: THIS COULD RESULT IN DRAGGING BRAKES, BRAKE FADE, ORPREMATURE WEAR AND/OR HEAT DAMAGE TO BRAKE SYSTEM COMPONENTS, REDUCING BRAKINGEFFICIENCY WHICH COULD RESULT IN AN ACCIDENT.

Rimedio del costruttore: INSTALL REVISED RETURN LINES AND REPLACE DAMAGED BRAKE SYSTEM COMPONENTS.

Difetto: BOLTS THAT ATTACH THE FRONT AXLE TRACK BAR BRACKET TO THE FRONT CROSSMEMBER MAY LOOSEN, ALLOWING THE FRONT WHEELS TO OSCILLATE WITH FRONT END SHIMMY.

Rischio: SEVERE SHIMMY COULD DAMAGE STEERING LINKAGE OR STEERINGGEAR, WHICH COULD RESULT IN LOSS OF STEERING CONTROL AND AN ACCIDENT.

Rimedio del costruttore: INSTALL REDESIGNED FRONT AXLE TRACK BAR TO CROSSMEMBER BRACKET AND IF NECESSARY, REPLACE CERTAIN STEERING COMPONENTS.

Difetto: THE INVOLVED VEHICLES ARE EQUIPPED WITH SAFETY COMPLIANCE CERTIFICATION LABELS AND INCOMPLETE VEHICLE DOCUMENTS THAT INDICATE THAT THE GROSS AXLE WEIGHT RATING (GAWR) IS APPROXIMATELY 0.6 TO 6.0 PERCENT GREATER THAN THE COMBINED LOAD CAPACITY OF THE TIRES AT THE SPECIFIED TIRE INFLATION PRESSURE. THIS FAILS TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 120, "AIR BRAKE SYSTEMS", AND 119, "NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS", OR 109, "NEW PNEUMATIC TIRES".

Rimedio del costruttore: OWNER WILL RECEIVE CORRECT LABELS BY MAIL, FREE OF CHARGE.