Volkswagen Passat

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas, Passat, Beetle, Beetle Convertible, Golf, Golf SportWagen and GTI and Audi Q5 and SQ5 vehicles. The brake caliper pistons on these vehicles may have insufficient coating, potentially reducing the brake performance.

Risiko: A reduction of braking performance can increase the risk of a crash.

Herstellerabhilfe: Volkswagen and Audi will notify their owners. Audi dealers will bleed the rear brakes. Volkswagen dealers will bleed the front and rear brake calipers. Note: Owners are advised not to drive their vehicles until the brake system has been checked. The recall began June 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 47N8, 47N9, and 47N6.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Atlas, Atlas Cross Sport, and Passat vehicles. The front wheel bearing bolts may have been incorrectly tightened.

Risiko: The bolts may loosen and cause a loss of control, increasing the risk of a crash.

Herstellerabhilfe: Dealers will inspect the tightness of the wheel bearing bolts and replace the bolts, as necessary, free of charge. Owner notification letters were mailed November 2, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40R7.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2020 Passat vehicles. The passenger frontal air bag may have been folded incorrectly affecting its deployment force. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risiko: An incorrectly folded air bag can deploy with too much force, increasing the risk of injury.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began October 14, 2020. Owners may contact Volkswagen customer service at 1-888-241-2289. Volkswagen's number for this recall is 69AY.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risiko: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Passat vehicles. Brake fluid may leak slowly from the some of the brake line connections, resulting in a low brake fluid level.

Risiko: A low brake fluid level may lengthen the distance needed to stop the vehicle, increasing the risk of a crash.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will replace the affected brake lines, free of charge. The recall is expected to begin in March 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 47N3.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and 2017-2018 Volkswagen Passat vehicles. The brake caliper bracket mounting bolts on these vehicles may not have been tightened sufficiently.

Risiko: The loose brake bracket bolts can allow the caliper to move, reducing braking ability or causing a loss of vehicle control and increasing the risk of a crash.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will inspect the brake caliper bracket bolt tightness, replacing and re-torque the bolts as necessary, free of charge. Additionally brake caliper fasteners, bleeder valve, and brake hose bolts will be checked and torqued to the correct specification, if necessary, free of charge. For Passat vehicles, dealers will also inspect the parking brake cable for proper connection, free of charge. The recall began September 14, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 46H6.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Volkswagen Jetta and Passat vehicles manufactured September 23, 2014, to October 9, 2014, and equipped with manual front seatback recliners. In the affected vehicles, the seatback recliner retaining bracket may not engage correctly, resulting in unexpected movement of the seatback.

Risiko: Unexpected movement of the driver's seatback may distract the driver, increasing the risk of a crash.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will inspect the assembly of the seatback recliner retaining bracket, correcting it as necessary, free of charge. The recall began in October 2014. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 72F1.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Passat vehicles manufactured May 18, 2015, to May 21, 2015. The affected vehicles have a brake line at the left rear wheel area that may not have been properly tightened.

Risiko: If the brake line was not properly tightened, it may leak brake fluid, causing a reduction in braking performance, lengthening the distance needed to stop the vehicle and increasing the risk of crash.

Herstellerabhilfe: Volkswagen has notified owners, and dealers will tighten the brake line fitting, free of charge. The recall began on June 11, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 47M3.

Defekt: Volkswagen of America, Inc. (Volkswagen) is recalling certain model year 2014 Jetta, Beetle, Beetle Convertible, and Passat vehicles equipped with a 1.8T engine and torque converter automatic transmission. In the affected vehicles, the O-ring seals between the oil cooler and the transmission may leak fluid.

Risiko: The leaking transmission fluid could contact a hot surface and result in a vehicle fire.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will replace the O-ring seals in the transmission oil cooler, free of charge. The recall is expected to begin on April 16, 2014. Owners may contact Volkswagen at 1-800-822-8987. Volkswagen's number for this recall is 38B9/9V.

Defekt: Volkswagen Group of America (Volkswagen) is recalling certain model year 2012-2013 Passat vehicles manufactured January 2011 through November 2012. In the affected vehicles, the low beam headlight bulb may become loose and lose electrical contact.

Risiko: A loss of low beam headlights may reduce the driver's visibility and increase the risk of a crash.

Herstellerabhilfe: Volkswagen notified owners, and dealers will replace the bulb holder, free of charge. The recall began in May 2014. Owners may contact Volkswagen at 1-800-822-8987. Volkswagens recall number associated with this campaign is 94G8/7V.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Passat vehicles, equipped with diesel engines and Direct-Shift Transmissions (DSG). The vehicle's underbody heat shield may not be long enough to protect the right half-shaft grease boot from heat, potentially resulting in a grease leak.

Risiko: If the leaking grease contacts a heated surface, such as the exhaust system and/or the diesel particulate filter (DPF), it could increase the risk of fire.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will replace the driveshaft heat shield, free of charge. The recall began on July 7, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23W5.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2012-2014 Passat vehicles equipped with TDI engines. Due to improperly assembled wire seals in a connector for an underbody sensor, water may enter and corrode the electrical connectors of the sensor, causing an electrical short.

Risiko: An electrical short can cause the electrical connectors of the sensor to overheat, increasing the risk of a fire.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will inspect the connector, replacing it as necessary, free of charge. The recall began in September. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23T3.

Defekt: VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2012 PASSAT VEHICLES, MANUFACTURED FROM JANUARY 18, 2011, THROUGH JUNE 1, 2011. DURING ASSEMBLY, THESE VEHICLES WERE BUILT WITH A DIESEL FUEL FILTER ELEMENT THAT MAY NOT SEAL CORRECTLY.

Risiko: OVER TIME, OR AFTER CERTAIN DRIVING DISTANCES, THESE VEHICLES ARE SUSCEPTIBLE TO FUEL LEAKAGE. LEAKING FUEL, IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Herstellerabhilfe: VOLKSWAGEN WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE DIESEL FUEL FILTER ELEMENTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Defekt: VW IS RECALLING 130 MY 2009 PASSAT, PASSAT WAGON, AND PASSAT CC VEHICLES. SOME VEHICLES MAY HAVE AN ELECTROMECHANICAL STEERING GEAR CONTROL UNIT THAT CAN MALFUNCTION DUE TO A DAMAGED CAPACITOR. IF THIS MALFUNCTION OCCURS, THE DRIVER'S STEERING INPUT IS NOT PROPERLY PROCESSED BY THE SYSTEM AND THE VEHICLE MAY NOT RESPOND AS THE DRIVER INTENDS. THIS DEFECT CAN ONLY OCCUR IMMEDIATELY AFTER VEHICLE START-UP WHEN THE STEERING WHEEL IS MOVED FOR THE FIRST TIME AND AT SPEEDS LESS THAN 5 MPH.

Risiko: DRIVER ATTEMPTS TO OVERCOME THE SYSTEM DURING MALFUNCTION WILL CAUSE (1) VIBRATIONS IN THE STEERING WHEEL; (2) THE STEERING SYSTEM MOTOR TO TURN OFF; (3) THE RED STEERING SYSTEM MALFUNCTION INDICATOR LIGHT TO ILLUMINATE; AND (4) AUDIBLE WARNINGS TO CHIME. A MALFUNCTIONING STEERING SYSTEM COULD LEAD TO A CRASH WITHOUT WARNING.

Herstellerabhilfe: DEALERS WILL REPLACE THE STEERING GEAR IN THE AFFECTED VEHICLES. THE RECALL BEGAN ON DECEMBER 5, 2008. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Defekt: VOLKSWAGEN IS RECALLING 4,079 MY 2008 PASSAT AND 2,500 MY 2009 TIGUAN PASSENGER VEHICLES EQUIPPED WITH 2.0T FSI ULEV II ENGINES. THESE VEHICLES HAVE AN ENGINE CONTROL MODULE (ECM) CONTAINING SOFTWARE THAT MAY NOT PROPERLY CONTROL ENGINE IDLE WITH THE AIR CONDITIONING TURNED ON. IN RARE CASES, THE ECM MAY UNEXPECTEDLY INCREASE ENGINE RPM.

Risiko: AN ENGINE SURGE CAUSED BY AN UNEXPECTED INCREASE IN ENGINE RPM MAY SURPRISE THE VEHICLE OPERATOR AND CAN RESULT IN A CRASH WITHOUT WARNING.

Herstellerabhilfe: DEALERS WILL INSPECT AND UPDATE THE ECM SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 30, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.

Defekt: ON CERTAIN '6' GENERATION PASSENGER VEHICLES, THE WIPER MOTOR MAY FAIL DURING HEAVY RAIN DUE TO EXCESSIVE MOISTURE ENTERING THE WIPER MOTOR. IF THIS HAPPENS, THE WIPERS CAN BECOME INOPERATIVE.

Risiko: THIS COULD LEAD TO REDUCED VISIBILITY INCREASING THE RISK OF A CRASH WITHOUT WARNING.

Herstellerabhilfe: DEALERS WILL INSTALL A SPECIAL COVER AND SEALING KIT. THE RECALL BEGAN ON JANUARY 12, 2007. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2016 Volkswagen CC, 2006-2010 Passat and Passat Wagon vehicles. Interruption of electrical power to the fuel pump control module may cause the fuel pump to fail.

Risiko: If the fuel pump fails, the engine will stall, increasing the risk of a crash.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will replace the fuel pump control module, free of charge. The recall began June 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20AE.

Defekt: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2006-2007 Volkswagen Passat sedan and wagon vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Risiko: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.

Herstellerabhilfe: Volkswagen will notify owners, and dealers will replace the front driver air bag inflator with an alternate inflator, free of charge. The recall began on April 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Q8. Note: This recall partially supersedes recall 16V-079.

Defekt: ON CERTAIN PASSENGER VEHICLES, THE LEFT AND RIGHT TIE ROD SECURING NUT MAY BE INSUFFICIENTLY TORQUED.

Risiko: AN INSUFFICIENTLY TIGHTENED TIE ROD NUT MAY LOOSEN, RESULTING IN SEPARATION OF A TIE ROD. THIS CAN CAUSE A LOSS OF STEERING CONTROL, WHICH COULD CAUSE A CRASH.

Herstellerabhilfe: DEALERS WILL INSPECT AND INSTALL NEW LEFT AND RIGHT TIE ROD SECURING NUTS AT THE PROPER TORQUED SPECIFICATION. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.

Defekt: CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.0L ENGINE WITH 147 KW MAY HAVE A VACUUM LINE THAT MAY FRACTURE AND BECOME DISCONNECTED AT LOW AMBIENT TEMPERATURES.

Risiko: IF THIS HAPPENS, THE BRAKE POWER ASSIST CAN BECOME INOPERATIVE, AND THE DRIVER WILL EXPERIENCE INCREASED EFFORT TO APPLY THE BRAKES POSSIBLY INCREASING VEHICLE STOPPING DISTANCE. THIS COULD LEAD TO A CRASH WITHOUT WARNING.

Herstellerabhilfe: DEALERS WILL INSTALL THE NEWLY DESIGNED VACUUM LINE. THE RECALL BEGAN ON JANUARY 12, 2007. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.

Defekt: CERTAIN SEDANS AND STATION WAGONS EQUIPPED WITH 4.0L W8 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE AFFECTED VEHICLES ARE EQUIPPED WITH TIRES OF THE MAXIMUM LOAD RATING INDEX 93H; HOWEVER, THEY SHOULD HAVE BEEN EQUIPPED WITH TIRES WITH THE LOAD RATING INDEX 97H.

Risiko: THESE VEHICLES SHOULD HAVE BEEN EQUIPPED WITH TIRES HAVING THE LOAD RATING INDEX 97H.

Herstellerabhilfe: DEALERS WILL REPLACE ALL FOUR TIRES WITH THE PROPER SIZE TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-822-8987.

Defekt: VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.

Risiko: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.

Herstellerabhilfe: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.

Defekt: VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.

Risiko: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.

Herstellerabhilfe: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Defekt: ON CERTAIN PASSENGER VEHICLES, THE ELECTRICAL PORTION OF THE IGNITION SWITCH ASSEMBLY CAN FAIL CAUSING THE HEADLIGHTS AND WINDSHIELD WIPERS TO BECOME INOPERATIVE.

Risiko: IF SUCH FAILURES OCCUR WHILE THE VEHICLE IS IN USE AT NIGHT OR IN RAINY OR SNOWY WEATHER, A CRASH COULD OCCUR.

Herstellerabhilfe: DEALERS WILL REPLACE THE ELECTRICAL PART OF THE IGNITION SWITCH ASSEMBLY. OWNER NOTIFICATION BEGAN NOVEMBER 20, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.

Defekt: LOCK NUTS USED TO HOLD THE LEFT AND RIGHT FRONT AXLES TO THE SUSPENSION STRUTS MAY NOT HAVE BEEN PROPERLY MANUFACTURED. THE LOCK NUTS MAY BREAK AND CAUSE SEPARATION OF THE AXLE FROM THE SUSPENSION STRUTS.

Risiko: SEPARATION OF THE AXLE CAN CAUSE THE VEHICLE TO PULL TOTHE SIDE OF THE SEPARATION AND RESULT IN LOSS OF VEHICLE CONTROL AND ANACCIDENT.

Herstellerabhilfe: REPLACE THE LOCK NUTS.

Defekt: IN THE EVENT THE ENGINE OVERHEATS AND THE VEHICLE IS OPERATED CONTINUOUSLY IN THAT CONDITION, THE COOLANT PRESSURE WILL RISE TO A LEVEL AT WHICH THE HEAT EXCHANGER COULD LEAK.

Risiko: A LEAKING HEAT EXCHANGER WILL ALLOW HOT COOLANT TO ESCAPE CAUSING INJURY TO THE DRIVER'S FEET OR COULD STEAM UP THE INTERIOR OF THE VEHICLE TEMPORARILY IMPAIRING THE DRIVER'S VISIBILITY, INCREASING THE RISK OF A VEHICLE ACCIDENT.

Herstellerabhilfe: DEALERS WILL REPLACE THE HEAT EXCHANGER ON THESE VEHICLES.