Hyundai Kona

Defekt: Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Palisade Tucson, 2023 Sonata, Elantra, and Kona vehicles. The electronic controller for the Idle Stop & Go oil pump assembly may contain damaged electrical components that can cause the pump controller to overheat.

Risiko: An electric oil pump assembly that overheats increases the risk of a vehicle fire.

Herstellerabhilfe: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect and replace the electric oil pump controller, as necessary, free of charge. Owner notification letters were mailed starting September 7, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 246.

Defekt: Hyundai Motor America (Hyundai) is recalling certain 2026 Kona vehicles. Due to a manufacturing error, the front steering knuckles may crack and break, which can result in a loss of vehicle steering control.

Risiko: A loss of vehicle steering control increases the risk of a crash.

Herstellerabhilfe: Dealers will inspect and replace the front steering knuckles, as necessary, free of charge. Owner notification letters were mailed March 5, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 295. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 7, 2026.

Defekt: Hyundai Motor America (Hyundai) is recalling certain 2024 Kona vehicles. The 12-Volt battery cables may chafe against the engine control module bracket and short circuit during a crash.

Risiko: A short circuit increases the risk of an engine compartment fire.

Herstellerabhilfe: Dealers will install sheathing over the wiring, free of charge. Owner notification letters were mailed February 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 252.

Defekt: Hyundai Motor America (Hyundai) is recalling certain 2024 Kona vehicles. The seat belt assemblies in the right and left rear seats may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupation Crash Protection" and 209, "Seat Belt Assemblies."

Risiko: A seat belt that does not function properly may not adequately restrain an occupant in a crash, increasing the risk of injury.

Herstellerabhilfe: Dealers will inspect and replace the seat belt retractor as necessary, free of charge. Owner notification letters were mailed November 21, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 250.

Defekt: Hyundai Motor America (Hyundai) is recalling certain 2020 Kona vehicles. The certification label may indicate incorrect Gross Axle Weight Rating (GAWR). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 567, "Certification" and 110, "Tire Selection and Rims."

Risiko: An incorrect GAWR could result in the vehicle being overloaded, increasing the risk of a crash.

Herstellerabhilfe: Hyundai will notify owners, and dealers will install new label stickers displaying the correct GAWR over the affected areas of the certification label, free of charge. The recall began March 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 187.

Defekt: Hyundai Motor America (Hyundai) is recalling certain 2019-2020 Elantra, 2019-2021 Kona and Veloster vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which could result in engine damage.

Risiko: A damaged engine may stall, increasing the risk of a crash. In addition, oil may leak onto hot exhaust components, increasing the risk of a fire.

Herstellerabhilfe: Dealers will inspect and, if necessary, replace the engine, free of charge. In addition, Hyundai will deploy Piston Ring Noise Sensing System (PNSS) software. Owner notification letters were mailed August 24, 2021. Owners may contact Hyundai customer service at 1-855-371-9460.