Toyota Celica

Defect: ON CERTAIN PASSENGER VEHICLES, THE FUEL TANK CHECK VALVE, LOCATED IN THE FUEL TANK INLET PIPE, MAY BECOME SEPARATED FROM THE INLET PIPE AND FALL INTO THE FUEL TANK. IF THE CHECK VALVE FALLS INTO THE TANK, FUEL MAY SPILL FROM THE FUEL INLET PIPE WHEN THE FUEL PUMP AUTOMATICALLY SHUTS OFF DURING FUELING.

Risk: THIS CONDITION MAY RESULT A FIRE IN THE PRESENCE OF AN IGNITION SOURCE.

Manufacturer fix: DEALERS WILL INSPECT AND, IF NECESSARY, REPAIR THE FUEL TANK CHECK VALVE. OWNER NOTIFICATION BEGAN APRIL 4, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Defect: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE LUMINOUS INTENSITY OF THE DAYTIME RUNNING LAMP (DRL) WILL BE MODIFIED TO MEET THE STANDARD REQUIREMENTS.

Manufacturer fix: DEALERS WILL INSTALL A RESISTOR, WHICH WILL DECREASE THE LUMINOUS INTENSITY OF THE DRL. THE RECALL BEGAN ON MARCH 16, 2005. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 1998-2000 RAV4, 1998-1999 RAV4 EV and Celica and 1997-1998 Supra vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.

Risk: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant, and increases the risk of serious injury or death.

Manufacturer fix: Toyota will notify owners, and owners will have the option to self-inspect, or have a dealer inspect the steering wheel on their vehicle to determine if their vehicle may be equipped with an affected inflator. Potentially affected steering wheel serial numbers will be inspected by a dealer. Based on the inspection, dealers will replace the front driver air bag inflator with an alternate one, as necessary. These repairs will be performed free of charge. The recall began August 28, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall is 20TB01 and 20TA01.

Defect: RIDE CONTROL IS RECALLING CERTAIN FRONT STRUT MOUNTS BRANDED AS GABRIEL RIDE CONTROL OR ARVINMERITOR, P/NOS. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE RATE PLATE.

Risk: THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.

Manufacturer fix: RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.

Defect: AIR BAG INFLATOR CASE WAS INCORRECTLY MACHINED.

Risk: IN AN ACCIDENT, THE AIR BAG MAY NOT DEPLOY, WHICH COULD RESULT IN INCREASED INJURY TO THE DRIVER.

Manufacturer fix: REPLACE AIR BAG INFLATOR UNIT.

Defect: DUE TO A FAULTY PRESS DIE USED IN MANUFACTURING ALTERNATOR PULLEYS, PULLEYS INSTALLED ON CERTAIN VEHICLES MAY CRACK AND BREAK DURING VEHICLE OPERATION. THE BATTERY WOULD THEN BE CONSTANTLY DRAINED WITHOUT RECHARGING.

Manufacturer fix: DEALER WILL REPLACE THE ENGINE ALTERNATOR PULLEYS ON THE INVOLVED VEHICLES WITHOUT CHARGE TO OWNERS.

Defect: HEATER HOSES ON THE INVOLVED VEHICLES MAY HAVE BEEN DAMAGED DURING INSTALLATION, RESULTING IN SHORTER SERVICE LIFE.

Manufacturer fix: HEATER HOSES WILL BE REPLACED ON ALL INVOLVED VEHICLES FREE OF CHARGE.